Fun, Learning, Friendship and Mutual Respect
START  HERE


Unregistered
Go Back   HeliFreak > R/C Helicopter Support > Thunder Tiger 30/50 > Titan X50


Titan X50 Thunder Tiger Titan X50 Helicopters


Reply
 
Thread Tools Display Modes
Old 07-15-2012, 01:53 PM   #1
KevinDudley
Registered Users
 

Join Date: Jan 2012
Location: US,White House,TN
Default Redline 53H engine vibration

Just completed a build on a Titan X50.
First Engine Start: Engine started with ONE burst of starter, ran fine at idle.

I noticed immediately an excessive vibration coming from the engine.
Even at idle the vibration "buzzes" your fingers if you touch the mixture needle or put your fingers on the engine itself.

The vibration translates clear through the tail boom and ALL parts are buzzing.

This is all at idle.

This cannot be correct.

This is a NEW X50, never flown, just completed kit, FIRST start on engine.

Any ideas??????

Thanks....
KevinDudley is offline        Reply With Quote
Old 07-15-2012, 05:31 PM   #2
KevinDudley
Registered Users
Thread Starter Thread Starter
 

Join Date: Jan 2012
Location: US,White House,TN
Default

My follow up......
I removed the engine and "balanced" the clutch disk by removing material on the top of the disk.

It was slightly out of balance.
I also "freed" up the bearings on the starter shaft. They were a near press fit and were very hard to get out. Biffed shaft with sandpaper so bearings would slide freely onto shaft.


I took them out and the starter shaft so I could shorten the starter shaft by 0.020" to be sure the engine crank shaft end was not pressing up against the starter shaft.

This seemed to free the starter shaft up slightly so that it would spin more freely.
Maybe mattered, maybe not.

Any, vibrations did reduce considerably.
I also think that when the engine is broken in and running "cleanly" in 2 cycle mode the vibes will be less.

Thanks....
KevinDudley is offline        Reply With Quote
Reply




Unregistered
Go Back   HeliFreak > R/C Helicopter Support > Thunder Tiger 30/50 > Titan X50


Titan X50 Thunder Tiger Titan X50 Helicopters

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump


Copyright © 2004-2011 - William James - Helifreak.com